Company about
Home > Polaris Sportsman > Polaris 500 Speedometer Not Working

Polaris 500 Speedometer Not Working


I have not seen a surface mount version of this speedometer in person so the instructions below do not necessarily apply. It is part # XXXXX§ion=230546&year=1999&make=Polaris&category=ATVs&dc=792&name=HANDLEBAR+and+HEADLIGHT+POD+%2D+A99CH50EBThank you again for trusting us with your problem. Remove the needle: This is sort of tricky and it is possible to ruin the speedometer with this step: Since you have already declared the speedometer to be a total loss, Sign in to make your opinion count. More about the author

Too much, you'll damage it that way, as well. Needle wouldn't move toward O at all without power but when I did the bench power test... I did the suggested repairs and when I placed my 1999 polaris sportsman 500 speedometer back in, it worked as it should. The main reason I tell you is it is not intuitive that the 4wd would be dependant on the speedo working and the speedo isn't cheap..There is always a possibility it

Polaris Sportsman 500 Awd Problems

Pin "C" is ground while pin "B" is the signal input. Part Number: 3280531. The one that I happened to used came from a junked VCR, was rated for 500 volts and happened to have a plastic tab rather than the metal tab of the hilinerider02-25-2009, 10:58 PM.. $59 later wham bam thank you man!!! :D this with the chicks you have with your cars too:eek::eek: oonighttrain02-26-2009, 07:40 AMthis with the chicks you have with your

If the odometer works and is anywhere in the ballpark, it would expect the wheel sensor to be OK.Since you have nothing to lose, check to see if the needle's spindle PDA View Full Version : polaris sportsman 500 4x4 speedo inop.. In at least one case noted in the comments above a repair made by soldering it back into place was successful - but that is likely a matter of luck!You may 2000 Polaris Sportsman 500 Speedometer Doesn't Work Long story short, I tested the transistor (it was fine) and then resoldered it into board and everything works now.

I will describe as best as I can the part that is for sale.97 Polaris Sportsman 500 Speedometer Gauges and cable $85.00Buy It NowFree Shipping1996 POLARIS SPORTSMAN 500 4X4 SPEEDO GUAGE Polaris Snowmobile. The TIP48 is different looking.

Back to top Biddyboo Posted April 18, 2008 - 06:50 PM #6 If the speedo is dead it could be a bad ground causing all your problems the speedo grounds your

Closed on Sundays. Polaris Sportsman 500 4x4 Problems Polaris Snowmobile. For the 3-pin connector they are A-C starting from the top and working down. Maybe I can e-mail it to you for comparison.

  • An additional test is that if you increase the voltage above 14-15 volts (but not above 20 volts!) the lights will not get any brighter - a sure sign that the
  • BigjermsGarage 100,467 views 10:00 How to bypass transmission switch polaris magnum sportsman 4WD AWD fix. - Duration: 4:44.
  • After 5-10 minutes (yes, it may take that long to slowly move back!) look again to see where it is pointing: If it isn't at zero, re-align the pointer and try
  • It can be a bit tricky to get purchase on the speedometer face and you might bend into a hook a small piece of metal such as a paper clip to
  • Ask john Your Own Question john, ASE Certified Technician Category: Motorcycle Satisfied Customers: 15056 Experience: mechanic 6149662 Type Your Motorcycle Question Here...
  • the by all means use it: These are very slightly more expensive but much higher quality and more rugged.
  • Polaris ATV Legend Member #193 Join Date: Feb 2009 Location: Port Angeles WA Posts: 20,004 Welcome to the board! __________________ I tried setting my password to "penis" but it said

2002 Polaris Sportsman 500 Speedometer

My 4 wheel drive works properly...on and off. The AWD does not work properly. Polaris Sportsman 500 Awd Problems There is some rust areas on the outer surface of the ring of the device that the needle actually goes into. 2001 Polaris Sportsman 500 Speedometer Not Working I purchased another used one they guy said it worked and it does the same thing as my old one did.

Ask an Expert Car Questions Motorcycle Questions How JustAnswer Works: Ask an Expert Experts are full of valuable knowledge and are ready to help with any question. This is a sensor attatched in such a way that it 'counts' the holes in the front brake disk (usually right side) to measure speed. Sometimes it will engage, sometimes it won't. Phil030 ATV Repair and Maintenance 1 04-23-2012 05:24 PM 04 awd NOT working, speedo does!!! Polaris Sportsman Speedometer Bypass

Loading... If this has happened to you, you probably ran it without a good battery: Read on to find out why you should never do that if you can help it! Make sure the holes in the rotors are cleaned and not all plugged up with mud. Sign in to add this to Watch Later Add to Loading playlists...

Back to top markgyver Posted April 15, 2008 - 03:44 PM #2 It is probably the speedo,The 4 wheel drive runs through the speedo.If the wires are plugged in replace the 1999 Polaris Sportsman 500 Speedometer Join Our Community! While both versions seem to have the same fate when used with a bad battery - and the "fix" is likely similar, I have not personally seen the newer surface-mount version.

Rating is available when the video has been rented.

Published on Aug 27, 2015Sportsman 500 with Broken Speedometer - I need to find a go to service center here in Utah to get this fixed. Reply With Quote 04-23-2008,07:23 AM #2 Donegal_TDI View Profile View Forum Posts Bronze Member Join Date Oct 2007 Posts 98 Location Donegal, Ireland Tractor SAME100.4 Kioti551C XUV855D Re: Electrical Problem with Figure 4: Location of the likely bad part(s). Polaris Speedometer Not Working Working...

See each listing for international shipping options and costs. Mark Jenkins 91,736 views 15:00 Loading more suggestions... There are several "fixes" on the internet but I would caution you that any bypass will defeat the safety feature on the machine. However, I am wondering if it is safe to do so.

I was thinking I will try a 5 amp to start with. If it works, the lights should come on and if you move the speedometer needle with your finger, up-scale, it should reset itself to zero much more quickly than it had It could also be that one of the large capacitors is damaged as well - especially if it shows any signs at all of swelling/bulging.Best of luck!DeleteReplyJamesJanuary 30, 2016 at 8:10