Company about
Home > Polaris Sportsman > Polaris Atv 4 Wheel Drive Not Working

Polaris Atv 4 Wheel Drive Not Working


By continuing to browse our site you agree to our use of data and cookies.Tell me more | Cookie Preferences LinkBack LinkBack URL About LinkBacks close Enter your email: Privacy the by all means use it: These are very slightly more expensive but much higher quality and more rugged. When that button is depresssed you get full power in reverse. Loading... More about the author

My needle never moves back toward O. Ivan Cingel 14,629 views 2:23 Polaris Trailblazer 250 - Top End Rebuild- Project $400--Part 2 - Duration: 9:43. You can read about them here.X LinkBack LinkBack URL About LinkBacks Home Forums Reviews Classifieds Articles Dealers Store Homepage Today's Posts Search Register Forgot your Password ?Sign Up Remember Me? The charging system's voltage regulator on these vehicles are fairly simple, but they depend strongly on the presence of the battery to moderate the wildly pulsating DC coming out of the

Polaris Sportsman 500 4x4 Wont Engage

SamCycleNS 3,698 views 7:09 2007 Polaris Sportsman Issue - No Juice - Duration: 2:19. Add to Want to watch this again later? Working...

  • Figure 1: The soft, black, aluminum ring around the perimeter of the speedometer that holds the faceplate to the body.
  • Posts: 377 It is hard to tell what kind of damage until you take it apart.
  • Maybe I can e-mail it to you for comparison.
  • Click on the image for a larger version.
  • Pin "C" is ground while pin "B" is the signal input.
  • So, I think I will just cross no.2 and no. 5 and I should be set.
  • Arctic Cat CAN-AM (BRP) KTM Honda Kawasaki Chinese Quads Kids Quads Polaris Suzuki Yamaha SxS / UTV Discussion Arctic Cat Prowler Kawasaki Mule and Teryx Polaris Ranger and RZR Yamaha Rhino
  • My 2001 500 H.O.
  • By continuing to browse our site you agree to our use of data and cookies.Tell me more | Cookie Preferences LinkBack LinkBack URL About LinkBacks Clubs, Garage Plus vBulletin Plugins

Tackle, Bait. Sometimes this is obvious (bulging, leaking, etc.) but not necessarily.If you are careful you should be able to connect the speedo without putting it in the case, but while the pins/connectors p0tr0ast is offline Quote Quick Reply Remove Advertisements Sponsored Links Advertisement post #2 of 9 (permalink) Old 01-12-2010, 12:49 PM Trikemaster Senior Member Join Date: Nov 2009 Polaris Sportsman 500 Speedometer Not Working Top Lower Navigation Polaris ATV Forum > Polaris ATV Technical Discussions > ATV Repair and Maintenance 4 Wheel Drive Problems « Previous Thread | Next Thread » Search tags for

Rating is available when the video has been rented. Polaris Sportsman 500 Awd Not Working briansmobile1 171,425 views 4:30 Polaris Sportsman 500 HO 4x4 - Front Axle, Rectifier, Starter Drive Etc. - Duration: 7:09. Also my speedo does light up and did work except the needle part( which I think is speed sensor) now 4 wheeler won't start unless you remove pin "c" black wire

Terms of Use x Cookie and Data Use Consent We use cookies to improve your experience on this website and so that ads you see online can be tailored to your

Sign in to add this to Watch Later Add to Loading playlists... 2004 Polaris Sportsman 500 4x4 Problems Working... Michigan-Sportsman Forums Out and About 4 Wheeling - ATVs Style CMG-UIX-Child Weekly Digest Home Contact Us Help Advertising Info Terms and Rules Privacy Policy Top ABOUT Founded in 1999, started in there!Best of luck - and let us know how it works out.DeleteReplyRoger EnglehartFebruary 2, 2016 at 8:14 PMHm?

Polaris Sportsman 500 Awd Not Working

whitty Polaris ATVs - Ask an Expert! 64 01-05-2016 03:29 AM 2004 sportsman 400 radiator guard question yellowpolaris Polaris 15 06-21-2015 12:13 PM 2005 Polaris Scrambler 500 Carb Clarification hoopduerr Polaris If there *are* filings in there it may be possible to blast them out with very carefully controlled compressed air. (If the unit that you have is at all similar to Polaris Sportsman 500 4x4 Wont Engage You can buy replacement waterproof connectors at good autoparts stores. __________________ RZR and a whole bunch of other off-road stuff. 2007 Polaris Sportsman 500 Awd Not Working Sign in Share More Report Need to report the video?

Do not use petroleum-based grease for this! I will send a picture of the back of the housing, it is the 6 prong fitting that in the picture. Start by checking the speedo, if that works then move down to the diff. Category Entertainment License Standard YouTube License Show more Show less Loading... Polaris Sportsman 4x4 Not Working

Now on a polaris the rear have to spin about an 1/8th of a turn befor the front will kick in. Yes, my password is: Forgot your password? Working... click site Both sides of the circuit board and most of the components are covered with a moisture resistant coating.

When I plug the harness in, no. 2 stays hot if the awd is NOT working, if it is working it is not hot. Polaris 4 Wheel Drive System Trikemaster is offline Quote Quick Reply post #6 of 9 (permalink) Old 01-13-2010, 10:38 AM Thread Starter p0tr0ast Junior Member Join Date: Jul 2009 Posts: 13 is my About Press Copyright Creators Advertise Developers +YouTube Terms Privacy Policy & Safety Send feedback Try something new!

Sleuthing the source of a SARSAT signal? ► September (2) ► August (2) ► July (1) ► June (2) ► May (3) ► April (1) ► March (3) ► February (1)

In so-doing, you'll also be removing the LCD odometer display. has nothing to do with AWD. Fortunately, you can "solder through" it although extra care should be taken to assure that the solder joints are clean and good. 2005 Polaris Sportsman 500 4x4 Not Working However, when I opened my speedo up, the board seems slightly different than what you have pictured in figure 4.

Contact Open the Quick Navigation CARBONTV Forum software by XenForo™ ©2010-2016 XenForo Ltd. First, note how far the needle is pushed on to the spindle: You'll want to remember this when putting it back on. You now have access to the component side of the circuit board. It is connected to the override button.

bigbucks160 replied Nov 14, 2016 at 4:18 PM Loading... Yesterday 02:14 PM by UK.CC52 101 Yokochrist Video Thread 11-11-2016 03:35 AM by yokochrist 0 Best Working-Quad for... 11-10-2016 01:52 PM by jrhan762 0 Question about pilot jet 11-08-2016 12:13 AM It could also be that one of the large capacitors is damaged as well - especially if it shows any signs at all of swelling/bulging.Best of luck!DeleteReplyJamesJanuary 30, 2016 at 8:10 If you do break something else, save up for a new speedo!

Posting Quick Reply - Please WaitPosting Quick Reply - Please Wait « Previous Thread | Next Thread Currently Active Users Viewing This Thread: 8 (0 members and 8 guests) Thread Thanks, ChuckReplyDeleteRepliesKA7OEIDecember 15, 2014 at 1:42 PMHi Chuck,Getting into the repair business is not a "can of worms" that I'd care to open at this time, having been involved in this The MPSA42 is a high-voltage, low-power NPN transistor of the type typically used in video drivers for cathode-ray tubes on older TVs and suitable equivalents may be found on the small