Using a small blade screwdriver, work your way around the perimeter of the inside of the speedometer, wedging gently between the outer body of the speedometer and the module itself, reaching In at least one case noted in the comments above a repair made by soldering it back into place was successful - but that is likely a matter of luck!You may Añadir a ¿Quieres volver a verlo más tarde? It amaizes me the number of people that do not know this....ALL 4 wheels turn on a Polaris. http://europrolink.com/polaris-sportsman/polaris-atv-4-wheel-drive-not-working.php
Inicia sesión para añadir este vídeo a una lista de reproducción. Cargando... Is your gear indicator showing your gear selection on your instrument cluster?? It says it's working, i'm not getting any blink codes, but my back tires are the only thing turning...
Mark Jenkins 90.330 visualizaciones 4:16 Polaris Sportsman 700cc issues and problems and solutions - Duración: 42:23. Posts: 377 polaris 500... On the back side of the speedometer module (the "component" side of the circuit board) you'll find four black screws that correspond approximately with the four corners of the LCD display. Cargando...
http://www.atvtime.com/phpBB2/viewtopic.php?p=116127&sid=00a5f6b5487aa0f67fc0c7a30cead999 #5 whatisup02, Mar 18, 2010 Dasher Expand Collapse 141 0 Trophy Points: 671 Location: waterford, mi. expertvillage 68.749 visualizaciones 2:16 How to Drain and Replace Hub Oil on a Polaris Sportsman 4x4 ATV - Duración: 4:16. It must show h l or r to give the ground. Polaris Sportsman 500 Speedometer Not Working What seems to kill these things is heat.
Categoría Motor Licencia Licencia de YouTube estándar Mostrar más Mostrar menos Cargando... Polaris Sportsman 500 4x4 Wont Engage Idioma: Español Ubicación del contenido: España Modo restringido: No Historial Ayuda Cargando... Cargando... All solders look great.
Not sure what it is but figure its what makes the needle turn. 2004 Polaris Sportsman 500 4x4 Problems In that way you could see what gets hot before putting things back together.Best of luck!DeleteReplyGteg82090January 12, 2016 at 4:46 PMHi there I loved this article. Both sides of the circuit board and most of the components are covered with a moisture resistant coating. Make sure that you also clean out the holes through the board!
The time now is 04:37 PM. http://www.michigan-sportsman.com/forum/threads/polaris-sportsman-250-and-500-4-wheel-drive-problem.329163/ Now, the only thing holding the speedometer module inside the case is friction and the silicone used to seal around the wiring connector pins on the back. Polaris Sportsman 500 Awd Not Working u-joints are $25 on ebay. 2007 Polaris Sportsman 500 Awd Not Working In my case, the heat of the original TIP48's destruction and its subsequent removal from the board actually damaged a trace so I had to repair it with a short piece
I got it on ebay and I was told it works properly. http://europrolink.com/polaris-sportsman/polaris-sportsman-4-wheel-drive-not-working.php April 3rd, 2013, 10:32 PM #2 switzomatic Feedback Score: 0 reviews Member #38370 Join Date: Apr 2012 Posts: 547 (0) Re: 4 wheel drive not working Going to An additional test is that if you increase the voltage above 14-15 volts (but not above 20 volts!) the lights will not get any brighter - a sure sign that the Arctic Cat CAN-AM (BRP) KTM Honda Kawasaki Chinese Quads Kids Quads Polaris Suzuki Yamaha SxS / UTV Discussion Arctic Cat Prowler Kawasaki Mule and Teryx Polaris Ranger and RZR Yamaha Rhino Polaris Sportsman 400 4x4 Not Working
LinkBack Thread Tools Display Modes #1 (permalink) 11-05-2012, 06:31 AM Steventabor Junior Member Member #31295 Join Date: Oct 2012 Location: Winston Salem NC Posts: 6 4 Wheel Drive A few comments: When putting the LCD back in place, it may be a good idea to wipe down the top and bottom edges of the rubber strips with an alcohol-wetted If the battery goes completely bad or is removed, the charging system goes haywire and the voltage can (apparently) exceed 20 volts (and is probably higher) and one can risk burning navigate to this website FLEETof4x4's 452 visualizaciones 0:07 Need for Speed™ 2015 trying to drift - Duración: 2:34.
You may notice that the LCD itself has a part number printed on it: Note its orientation so that you can put it back in the correct orientation. Polaris Sportsman 4x4 Not Working It seems to read higher than actual speed. I have a 2001 400 with speedo/lights/and 4wd inoperative.
Join Date: Jun 2008 Location: North Texas Posts: 19,287 If you already had battery problems(not holding a charge because of age or a regulator/rectifier problem) it's possible you had a surge on a polaris 4x4 does mean all 4 wheels are going to turn. I cracked the shaft of the dial. 2005 Polaris Sportsman 500 4x4 Not Working I happened to have some ZTX458 transistors - devices that had equal or better voltage/current specs than the original - laying around from another project and used one of them.
Odomer, trip, mileage, hours and lights all work and 4x4 turns on and off. Both the speedometer should go up and the odometer should (slowly!) increment.DeleteK WellsMarch 13, 2015 at 4:14 PMI think I messed up. Assume from the beginning that the speedometer is a total write-off and that you would have to replace it, anyway, to get it working again. http://europrolink.com/polaris-sportsman/polaris-xplorer-400-4-wheel-drive-not-working.php When I changed the seals in the front diff earlier this year I noticed damage to the insulation on the wires.
Alexys Pilon-Gagnon 5.358 visualizaciones 1:57 Polaris ATV Maintenance & Repair Tips : Polaris ATV Thumb Throttle Maintenance Tips - Duración: 2:16. LFTS 11/14 walleyerick replied Nov 14, 2016 at 4:31 PM WOW - Chicago Cubs must... Any quick way to do the audio Audio HZ test? Let me explain.
The unit must be powered up in order for the speedometer - and odometer, for that matter - to indicate. If you are successful in your repair and can provide some information that might be useful, I'd be happy to post that information here and give credit where credit was due Cola de reproducciónColaCola de reproducciónCola Eliminar todoDesconectar Cargando... Figure 4: Location of the likely bad part(s).
Farming, Beef, Dairy, Insect, Equipment, ETC. Cargando... Cargando... Inicia sesión para añadir este vídeo a la lista Ver más tarde.
Theme designed by Audentio Design. other than chunks of metal?