Company about
Home > Polaris Sportsman > Polaris Speedometer Not Working

Polaris Speedometer Not Working


If it doesn't come out on its own, carefully remove it - noting the markings on the LCD and which way they were oriented with respect to the board. Is this a indication of a bad diode?ReplyDeleteRepliesKA7OEIApril 4, 2015 at 12:23 PMIn the picture, the "bad" part had no visual indication of there being anything wrong with it. This OEM Gauge assembly also has integrated Trip, Odometer and Fuel Gauge. Sometimes this is obvious (bulging, leaking, etc.) but not necessarily.If you are careful you should be able to connect the speedo without putting it in the case, but while the pins/connectors click site

The time now is 02:31 PM. -- RZR v2 -- .Mobile Style. - Contact Us - Advertise - Polaris RZR Forum - RZR - Polaris ATV Forums - Archive - would it have a cable? I appreciate the quick response and very thorough "How To" guide for the repair overall.ReplyDeleteRepliesKA7OEIFebruary 3, 2016 at 3:35 PMFrom what I can tell the circuits are similar, so there should As far as I can tell the only thing missing is the rev cap for engagement - that will have to be the riders discretion.

Polaris Sportsman Speedometer Problems

Quick fix and doesn't cost too much. In so-doing, you'll also be removing the LCD odometer display. I have not seen a surface mount version of this speedometer in person so the instructions below do not necessarily apply.

The time now is 01:31 PM. -- .Mobile Style. -- PAF v2 - Contact Us - Advertise - Polaris ATV Forum - Archive - Privacy Statement - Top Powered by vBulletin With the ring removed you should be able to use your fingernails and pry the front, clear cover from the body of the speedometer. There are at least two versions of speedometers used in the late 1990's and early 2000s - the one that, inside, looks like Figure 4 with "through-hole" components and a slightly 2001 Polaris Sportsman 500 Speedometer Not Working Polaris RZR Forum - RZR > General RZR > General RZR Discussion Speedometer not working User Name Remember Me?

These are moisture absorbers and they sit in a slight recess one one side of the case. Polaris Sportsman 800 Speedometer Not Working On the back side of the speedometer module (the "component" side of the circuit board) you'll find four black screws that correspond approximately with the four corners of the LCD display. Fortunately, you can "solder through" it although extra care should be taken to assure that the solder joints are clean and good. my company One side note, the 2000 Polaris had a circuit board with more surface mount components.

Feedback Score: 3 reviews First Name: steve My RZR: Faster than yours! 2002 Polaris Sportsman 500 Speedometer take out the pod ant if you use a thin blade or screwdriver you can get the clear plastic off. I must have got a short in a connection. Are these known for bad speedos?

Polaris Sportsman 800 Speedometer Not Working

My 2001 500 H.O.

Is the needle suppose to be real easy to turn? Polaris Sportsman Speedometer Problems With a bit of practice you can firmly slide the screwdriver along the perimeter and straighten out that soft, aluminum ring and you will probably have to go around several times Polaris Sportsman 500 4x4 Not Working the speedo is analog and the odometer is digital.

Again, there seems to be a (newer?) version of the speedometer with more surface-mount parts that can suffer the same fate. Figure 4: Location of the likely bad part(s). Open the speedometer: Place the speedometer face down on a clean, un-cluttered work area on a surface that you don't mind scratching: It's recommended that you put a rag or old Posted by KA7OEI at 5:34 PM Email ThisBlogThis!Share to TwitterShare to FacebookShare to Pinterest Labels: 4 wheeler, Polaris, speedo, speedo repair, speedometer, speedometer repair, Sportsman, Sportsman 500 47 comments: polarispartsshopNovember 12, Polaris Sportsman 500 Awd Problems

November 6th, 2009, 10:39 PM #2 johnnycat8 King of crash! All I did was ground the brown/white wire that comes from the 2 hub coils and goes to the speedo (they eventually join to become 1). If you see an area that has been crushed, open up the loom and take a look. __________________ April 18th, 2014, 02:34 AM #6 Moonshine56[OP] Feedback Score: 0 reviews navigate to this website Note the orientation of the writing on the LCD with respect to the board.

Arctic Cat CAN-AM (BRP) KTM Honda Kawasaki Chinese Quads Kids Quads Polaris Suzuki Yamaha SxS / UTV Discussion Arctic Cat Prowler Kawasaki Mule and Teryx Polaris Ranger and RZR Yamaha Rhino Polaris Sportsman Speedometer Bypass Squirt a dab of silicone grease (but not silicone seal!) this in each of the electrical connectors on the back side: This will help prevent ingress of moisture as well as Polaris Snowmobile.

Tach, odometer, fuel gauge, everything else works but when moving the dial does not move. ...

  1. You have answered all questions before I evean started.DeleteKA7OEIOctober 10, 2016 at 12:54 PMGlad to hear - hopefully you were able to repair your speedometer.DeleteReplyBrent BivensJune 5, 2014 at 8:48 PMGreat
  2. User Agreement, Privacy, Cookies and AdChoice *Learn about pricingThis page was last updated: Nov-14 14:31.
  3. I replace it with a used one and no change.
  4. The voltage should be no more than 2-3 volts below the supply voltage to the speedo.
  5. I compliment you for doing that. __________________ April 21st, 2014, 06:19 PM #13 Moonshine56[OP] Feedback Score: 0 reviews Member #63796 Join Date: Dec 2013 Posts: 13 (0)
  6. After inspecting for damaged traces, install the new components.
  7. Off Road Parts.POLARIS SPEEDOMETER SPORTSMAN 600 700 2002 2003 500 6x6 3280425 Tested! $299.99Buy It NowFree Shipping2006 POLARIS SPORTSMAN 500 C SPEEDOMETER $179.99Buy It NowFree Shipping00 Polaris Sportsman 335 Speedometer with
  8. This coating is slightly rubbery and when soldered, it gets discolored.
  9. Aaron Rose 5,201 views 2:06 2004 Polaris Sportsman 600 AWD Fix - Duration: 1:50.

Good to know. characters left:

Contact Us|Terms of Service|Privacy & Security|About Us|Our Network|Sitemap © 2003-2016 JustAnswer LLC JustAnswer UKJustAnswer GermanyJustAnswer SpanishJustAnswer Japan 31 10574085 SnoWest Snowmobile Forum > SnowTalk > Fouled Plug > polaris sportsman 500 4x4 running makin trax afco shocks and springs November 6th, 2009, 10:41 PM #3 crazywatson Just kidding! Polaris Sportsman 400 4x4 Not Working Odomer, trip, mileage, hours and lights all work and 4x4 turns on and off.

Glad it was an easy fix. I would expect something like "1k" or "50k" (e.g. 1-3 numbers followed by the letter "k" or, less likely some numbers in front of "M") or just three numbers together - Last year, a friend of mine had the battery go bad on his 1999 Polaris Sportsman 500 4-wheeler. There is a speed sensor mounted on one of the front brake rotors.